Recent content by chevman

cool just was wanting to make sure. why a 10-12 psi higher reading when I engage the rear air? also should I check with the rear air on or off?

sorry it is the 2005 ext Lt I didn't thank the swb had rear air?

Have small leak added 1 16oz can last May worked great till yesterday checked pressure and it was low again so I added another can yesterday working great again but here is the question I checked the pressure with ac on high it is within the range on the gauge then I turned on the rear air and...

where is the hvac B fuse? thanks

sorry it is 2005 ext 4x4 68,000 I have tried from front by gear shift also from rear everything seems to work ie blower changes speed onls problem is I turn the temp all the way down 60 front is super cold but the rear the vents in the headliner are warm/hot this just started the rear used to...

front ac blowing cold but the rear is blowing warm/hot???

it is engaging while you are rolling then it is good it is your disconnect that is the problem just slap a new disconnect on and reuse the actuator and you'll be good to go:smile:

if you took it off and seen it working I would bet it is fine mine had the same yellow greese and I reused it with no problem:thumbsup:

I went with the doorman unit here is the link Amazon.com: Dorman 600-115 4WD Actuator Housing: Automotive also atp makes one here is that link Amazon.com: ATP 111001 Front Axle Disconnect: Automotive

yes it does now I found out mine would not engage when I got stuck in snow drift put in 4 hi, 4awd, 4lo and all I hear is a clicking sound do some testing and after I drive it for a bit it would engage but not from a stop now with the new disconnect no problems it locks right in I agree it is a...

I just went through the same thing clicking and would not engage from a stop but if I was rolling it would engage and only 53,000 on my tb is was the disconnect got a new one and fixed the problem im 99.9% sure you have a bad/worn disconnect.

went with the doorman unit I will update the progress of the unit also selling the old one if anyone is interested I will take 100.00+shipping for it looks as if only the bearings need replaced thanks steve

got the new disconnect today thanks amazon prime!! put it on and works like new!! the part was so much easier to install than I thought it would be the old unit did not look bad to me just a little dirty grease but the new one took care of the problem is there much of a market for the old...

I am looking for a transfer case for a coworker he has an 2004 tb are there any advantages/disadvantages on the year of tb it comes from? thanks

ok thanks for the info I will be going with a new one. thanks